Service Of Electrical Equipment For The Period Of Two Years (2024-2026) At Devi Ahilya Bai Holkar Airport, Indore.- PUMPS 1 Lifting and Lowering of Submersible Pump below ground level upto 450 ft including transportation,loading,unloading charges, bearing and greasing etc. complete as required. 3 Phase, upto 10 HP Job 2 Complete rewinding of the motor of following capacity Sewage / Drainage Submersible/ Submersible Pump Set of various makes & models i/c dismantling, transportation from site to work shop & work shop to site assembling, testing and commissioning etc. complete as required. 2.1 3 Phase, Greater than 7.5 HP Job 2.2 3 Phase, Greater than 01 HP & upto 3 HP Job 2.3 3 Phase, Greater than 03 HP & upto 5 HP Job 2.4 3 Phase, Greater than 05 HP & upto 7.5 HP Job 2.5 3 Phase, 10 HP Job 3 Complete rewinding of the motor of 3 Phase 7.5 HP Vertical Inline Multi Stage Hydro Pneumatic Centrifugal Pump Set of various makes & models i/c dismantling, transportation from site to work shop & work shop to site, assembling, testing and commissioning etc. complete as required. Job 4 Complete rewinding of the motor of following capacity Monoblock Pump Set of various makes & models i/c dismantling, transportation from site to work shop & work shop to site, assembling, testing and commissioning etc. complete as required.:- 4.1 1 Phase, upto 1 HP Job 4.2 3 Phase, upto 1 HP Job 4.3 3 Phase, Greater than 01 HP & upto 3 HP Job 4.4 3 Phase, Greater than 03 HP & upto 5 HP Job 4.5 3 Phase, Greater than 05 HP & upto 7.5 HP Job 4.6 3 Phase, 10 HP Job 4.7 3 Phase, 12.5 HP Job 4.8 3 Phase, 75 HP Job 5 Complete Servicing & overhauling of following capacity Sewage / Drainage Submersible Pump Set of various makes & models i/c replacement of defective parts, bush, bearings, mechanical seal etc., dismantling, transportation from site to work shop & work shop to site, assembling, testing and commissioning complete as required. 5.1 3 Phase, upto 1 HP Job 5.2 3 Phase, Greater than 01 HP & upto 3 HP Job 5.3 3 Phase, Greater than 03 HP & upto 5 HP Job 5.4 3 Phase, Greater than 05 HP & upto 7.5 HP Job 6 Complete Servicing & overhauling of following capacity Vertical Inline Multi Stage Hydro Pneumatic Centrifugal Pump Set of various makes & models i/c replacement of defective parts, bush, bearings, mechanical seal etc., dismantling, transportation from site to work shop & work shop to site, assembling, testing and commissioning complete as required.:-3 Phase 7.5 HP Job 7 Complete Servicing & overhauling of following capacity Monoblock pump Sets of various makes & models i/c replacement of defective parts, bush, bearings, mechanical seal etc., dismantling, transportation from site to work shop & work shop to site, assembling, testing and commissioning complete as required.:- 7.1 1 Phase, upto 1 HP Job 7.2 3 Phase, upto 1 HP Job 7.3 3 Phase, Greater than 01 HP & upto 3 HP Job 7.4 3 Phase, Greater than 03 HP & upto 5 HP Job 7.5 3 Phase, Greater than 05 HP & upto 7.5 HP Job 7.6 3 Phase, 12.5 HP Job 7.7 3 Phase, 75 HP Job 8 Complete Servicing, Repairing & Overhauling of following capacity Twin Lobe Rotary Air Blower of capacity 216 cubic mtr / hour at 0.4 Kg / Sq.Cm pressure & compatible with V-belt drive of 7.5 HP, 1440 rpm 3 Phase Induction Motor i/c replacement of defective parts, bush, bearings, mechanical seal etc., dismantling, transportation from site to work shop & work shop to site, assembling, testing and commissioning complete as required. (Make - Usha, Model - UGRK-140SR) Job STP WORKS 9 Regeneration of Water Softner Plant of STP having Brine Water Tank Capacity of 500 Ltrs, by supplying & topping up of Rock Salt / Common Salt @ 50 Kg per regeneration, on Monthly basis, or as per direction of Engineer-in-Charge, complete as required. Job 10 Providing & fixing of Filter press cloth for 140 KLD STP plant i/c dismantling of old filter press cloth as required. Job 11 Testing of Treated Water Sample of STP through MP Pollution Control Board / NABL accredited Laboratories and submission of Test Reports for following parameters, at regular interval of every 06(Six) months, or as per direction of Engineer-In-Charge, complete as required :- Colour, Odour, PH Value, TDS, TSS, BOD, COD, Oil & Grease etc. Sample 12 Chemical Dosing of 140 KLD STP through suitable means by providing Sodium Hypo Chlorite ,Lime Powder ,Alum Powder ,Poly Electrolite etc.to maintain the treated water as per standard parameters of pollution control board as mentioned in SCC , as per direction of Engineer -in-charge, complete as required. Month 13 Supply and replacement of existing tube settler media of 140 KLD ST plant including removal and dispose of existing tube settler media carfeully, complete as required. cum 14 Supply, installation, testing and commissioning of tube diffuser in different tanks of 140 KLD ST plant including removal and dispose of existing damaged tube diffuser carefully, complete etc as required. Each 15 Design,fabrication, supply, installation,testing and commissioning of bar screen of suitable size made out with stainless steel grade of ss304. Design shall be approved by Engineer InCharge, complete etc as required. kg FANS 16 Rewinding, repairing and overhauling of following types of fans by using suitable gauge enamel copper wire, backing, oiling, greasing including replacement of capacitor, bush, bearing, shaft etc, complete, as required 16.1 Ceiling fan (1200 mm to 1400mm sweep) Each 16.2 Wall Fan ( 300mm to 450 mm sweep) Each 16.3 Exhaust fan (up to 225 mm size) Each 16.4 Exhaust fan (300 to 450mm sweep) Each CABLE WORKS 17 Supplying and Making Straight Through cable jointing with heat shrinkable jointing kit complete with all accessories including ferruls suitable for 3 x 300 Sq.mm XLPE aluminium conductor cable of 33 KV grade as required. Set 18 Supplying and making indoor cable end termination with heat shrinkable jointing kit complete with all accessories including lugs suitable for 3 x 300 Sq.mm XLPE aluminium conductor cable of 33 kV grade, as required. Set 19 Supplying and Making Straight Through cable jointing with heat shrinkable jointing kit complete with all accessories including ferruls suitable for 3 x 185 Sq.mm XLPE aluminium conductor cable of 33 KV grade as required. Set 20 Supplying and making indoor cable end termination with heat shrinkable jointing kit complete with all accessories including lugs suitable for 3 x 185 Sq.mm XLPE aluminium conductor cable of 33 kV grade, as required. Set 21 45 KV high pot testing charges for 33 KV grade 300 Sq.mm HT cable. Job 22 45 KV high pot testing charges for 33 KV grade 185 Sq.mm HT cable. Job 23 Supply and making outdoor cable end termination with for 3 x 300 Sq.mm XLPE aluminium conductor cable of 33 kV grade, including disconnection of existing 3x300 sq.mm 33kV grade XLPE aluminium conductor cable from 9m Oudoor Pole at HT yardetc. as required. Job 24 Making outdoor cable end termination with for 3 x 300 Sq.mm XLPE aluminium conductor cable of 33 kV grade, including disconnection of existing 3x300 sq.mm 33kV grade XLPE aluminium conductor cable from 9m Oudoor Pole at HT yardetc. as required. Job 25 HT cable insulation testing with 5 KV insulation testing before & after cable jointing and termination work of standby HT cable testing and successful charging with proper HT pera tapping and M-sealing. Job PAINTING 26 Painting with one or more coats of spray painting with synthetic enamel paint of approved colour, brand and manufacture to give an even shade including cleaning of surface, on old work / electrical panels & installations, as required. Sq. Mtr. 27 Painting of following poles in 2 coats by using Aluminium paint of approved make (Asian / Berger) including pole boxes, cleaning of surface etc., as required including rewriting the identification Sl.No. 80 mm Dia Gl pipe pole of length not exceeding 2 Mt. Each VISIT CHARGES 28 Visit charges of Service Engineer from the Manufacturer or Authorised Service Dealer or Specialised Agency for carrying out Minimum 01(One) Half Yearly Preventive Maintenance visit for satisfactory working condition of the system including providing & upgrading Software, if required (OR) Breakdown maintenance visit as and when required basis till the complete rectification of the breakdown irrespective of number of visits to attend the same breakdown ( excluding cost of Spares / Hardware required, if any). 28.1 DG Sets Synchronizing Panel comprising of Auto Load Sharing and Load Managing Panel, Main Change Over Panel, PLC etc. at NPH (Make - Zeta Industrial Corp. Pvt Ltd.) Job 28.2 Vertical Inline Multi Stage Hydro Pneumatic Centrifugal Pump Set (3No. X 7.5HP) with Electrical Panel at NPH (Make - Grundfos/KSB/Kirloskar ) Job 28.3 For Fire Alarm control panel , 7 Loop intelligent analogue addressable, expandable, networkable at NITB. Work includes updating / editing / adding / disabling of devices etc complete as required. (Make- Honeywell, Model - XLS -1000):- Job 28.4 For Fire Alarm control panel , 2 Loop analogue addressable, at OTB (Make- Notifier, Model - NFS -3030) Job 28.5 For Fire Alarm control panel system Microprocessor based , 6 Zone control panel , with Auto Dialer Facility, installed at GP/LLZ/DVOR/NDB/TECH BLOCK (Make- Agni Suraksha / System Sensor) :- Job TRANSFORMER 29 Collection of Transformer Oil sample from Transformers of different capacities at site and testing the same from authorised testing laboratory and submission of test report for following parameters, complete as required :- (i) Acidity Test (ii) Flash Point Test Job 30 Dehydration & Filtration of 1600 KVA, 33/0.433 KV Transformers having oil capacity approx.2205 Ltrs at site including Testing of Transformer Oil B.D.V Test before and after Filtration for Transformers of following capacity. The job includes transportation of Filtration Machine etc. at site and submission of Test Reports, complete as required:- Job 31 Dehydration & Filtration of 1000 KVA, 33/0.433 KV Transformers having oil capacity approx 1525 Ltrs at site including Testing of Transformer Oil B.D.V Test before and after Filtration for Transformers of following capacity. The job includes transportation of Filtration Machine etc. at site and submission of Test Reports, complete as required:- Job 32 Supply of brand new Transformer oil suitable for 33/0.433 KV Power Transformers alongwith Test Reports of oil. Litre 33 Inspection, Servicing and Testing(all tests) of 1000 KVA, 33/0.415 KV Transformers including replacement of silica gel, rectification of any oil leakage etc. as required at site along with submission of test report. JOB 34 Inspection , Servicing and Testing of 100 KVA , 3.3 / 0.433 KV Dry Type Transformer i/c carrying out Insulation Test HT / LT side with 5 KV / 1 KV Meggar , Voltage Ratio Test , Magnetic Balance Test , Tightning of Stamping , Removing of Moisture if Insulation value low and Insulation Testing of 3.3 KV HT Cable etc. as required at site. JOB ACB 35 Inspection, Repairing, Servicing, Overhauling and Testing of following GE / C&S / ABB make Air Circuit Breakers from Manufacturer or Authorised Service Dealer or Specialised Agency and submission of Test Report etc., complete as required. 35.1 1000/1250/1600 Amps Each 35.2 2500 Amps Each HT PANEL 36 Inspection, Servicing / Overhauling and Testing of following HT Panels from Manufacturer or Authorised Service Dealer or Specialised Agency and submission of Test Report etc., as required. 36.1 33 KV Panel consisting of 33 KV VCB. Jyoti Make Each 36.2 33 KV Panel consisting of 33 KV VCB. ABB Make Each 36.3 33 KV Panel consisting of 33 KV VCB. Schneider Make Each RELAYS 37 Checking, Servicing, Calibration & Testing of protection relays provided on 5(Five) nos. Jyoti Make 33 KV VCB panels from Manufacturer or Authorised Service Dealer or Specialised Agency and submission of Test Report etc. as required.a) IDMT O/C & Earth fault relays (3 OC + 1 EF) - 05 Setb) Master Trip Circuit relay - 05 Nos.c) Trip Ckt Supervision relay - 05 Nos.d) Under / Over Voltage Protection Relay - 01 No.e) Restricted Earth Fault relay - 04 Nos.f) Buchholz relay trip / alarm, Winding Temp. trip / alarm, Oil Temp. trip/alarm, OSR trip/ alarm, MOG alarm - 03 Set Job 38 Checking, Servicing, Calibration & Testing of protection relays provided on 1(One) no. ABB Make 33 KV VCB panels from Manufacturer or Authorised Service Dealer or Specialised Agency and submission of Test Report etc. as required.a) IDMT O/C & Earth fault relays (3 OC + 1 EF) - 05 Setb) Master Trip Circuit relay - 05 Nos.c) Trip Ckt Supervision relay - 05 Nos.d) Under / Over Voltage Protection Relay - 01 No.e) Restricted Earth Fault relay - 04 Nos.f) Buchholz relay trip / alarm, Winding Temp. trip / alarm, Oil Temp. trip/alarm, OSR trip/ alarm, MOG alarm - 03 Set Job V/M AND A/M 39 Checking, Calibration & Testing of Voltmeter, Ammeter, Multifunction meter provided on different HT Side panels from manufacturer or Authorised Service Dealer or Specialised Agency and submission of Test Report etc. as required.a) Digital Ammeter -06 Nos.b) Digital Voltmeter - 02 Nos.c) Digital Multifunction Meter - 03 Nos.. Job 40 Checking, Calibration & Testing of Voltmeter, Ammeter, Multifunction meter provided on different MV/LT side panels panels from manufacturer or Authorised Service Dealer or Specialised Agency and submission of Test Report etc. as required.a) Digital Ammeter -65 Nos.b) Digital Voltmeter - 66 Nos.c) Analog Voltmeter - 04 Nos.d) Digital Multifunction Meter - 52 Nos.. Job DG SETS 41 Emission Testing at site for DG sets installed at DABH Airport through NABL Lab/approved Lab by CPCB for all parameters i.e. PM, SO2,NOX, CO etc complete as required. Job DEWATERING PUMP 42 B Check service visit including supply of following spares for Mahindra and Mahindra make Engine[38.1 kW @1500 rpm] of Dewatering pump located at NITB D.A.B.H Airport, Indore. SERVICE KIT FOR ELEMENTS OF FUELENGINE OIL FILTERCoolant Valvoline POWERZEN EXLE Oil 15W40 6.75Ltr. PRIMARY AIR ELEMENT - 75 HP SAFETY AIR ELEMENT - 4575GM per visit MISCELLANEOUS 43 Decoration of NITB/OTB on the occasion of INDEPENDANCE DAY /REPUBLIC DAY or other special occassions on hiring basis with minimum following type of arrangement, for duration of 3 days on each occassion, and other electrical decorations upto the satisfaction of EIC :- a) Tri-colour/Colour LED Series Riser Lights (approx. 25 feet. length) & accessories , including supply and installation of lights with suitable mounting arrangements, wiring / cabling, loading, unloading, transportation, dismantling etc. - Qty 500 Nob)LED series lights-40ft minc)PAR lights- 100 Nos Mind)NImar Lights-30 Nos Job 44 Erection of metallic pole of 5 mtr length in cement concrete 1:3:6 (1 cement : 3 coarse sand : 6 graded stone aggregate 40 mm nominal size) foundation using J hook of min 0.5 mtr including excavation and refilling, installation of LED flood light on pole complete etc. as required. Job 45 Repairing of existing earth pits of Transformers, DG sets, HT/LT panels near NITB sub-station cutting/drilling of strip replacement of nut-bolts, including brick work, plaster & painting complete etc. as reqiored Job 46 Cutting groove of size 50 mm. wide and 120 mm. deep (or as required) with Concrete cutting machine, laying of 25/40 mm. dia GI pipe, refilling and finishing the surface with ratio 1:1½:3 (1 Cement: 1½ coarse sand : 3 graded stone aggregate) cement concrete etc. complete as required. mtr 47 Cutting groove of size 50 mm. wide and 120 mm. deep (or as required) on existing flooring(granite/vertified tiles. etc) using appropriate tools and equipment for wiring works, and filling the grooves with appropriate materials(as per approval of EIC) to match the existing floor level and surface and ensuring a smooth and even surface, Restoring the floor to its original condition, including polishing, sanding, or other finishing techniques to blend the repaired areas with the surrounding floor and making the floor as good as or better than its original state, with no or less visible signs of the groove cutting and collecting and disposing all dust and debris generated during the cutting process etc. complete as required. mtr 48 Carrying out In-field test for measurement of intensity, beam spread and oreintation (4 Cs i.e. Configuration,Colour, Candela and Coverage) of the following Airfield Ground Lights(07/25 Runway) as per ICAO/CARrequirements by using vehicle mounted mobile testing equipment, including submission of test reports etc. complete as required. Job 49 Replacement of faulty LED fittings installed at the ceiling truss of the NITB with height of approximately 25 meters, with existing LED fittings as required,adhering to all necessary safety standards including safety helmets, Safety Goggles, Hand Gloves, Safety harness lanyards, Fall arrestors, Roof anchors and any other provisions as per requirement. Job 50 Perform on-site testing to accurately locate faults in Low Tension (LT) and High Tension (HT) cables using a cable fault locator equipment,and identification of fault locations to minimize downtime and ensure the rapid restoration of cable functionality and shall include Fault Pre-location,Fault Pinpointing,Verification Testing etc Job 51 Disconnection of existing 3x300 sq.mm 33kV grade XLPE aluminium conductor cable from 9m Oudoor Pole at HT yard and connection of 3 x 300 Sq.mm XLPE aluminium conductor cable of 33 kV grade with existing cable end termination, etc. as required. Job Total of SH: I SH:II ACMC of ACs, Water Coolers and Water Purifiers 52 Annual Comprehensive Maintenance Contract of the following Capacity AC units (including compressor) installed at various locations in the Airport Premises as per general and special terms and conditions attached. 52.1 1 TR Window/split Type AC Units (23 Units per year) Job 52.2 1.5 TR/ 2.0 TR Window/split Type AC Units (89 Units per year) Job 52.3 3.0 TR Split/Cassette Type AC Units (22 Units per year) Job 53 Annual Comprehensive Maintenance Contract of the following Capacity Conventional Type Water Coolers (including compressor) installed at various locations in the Airport Premises as per general and special terms and conditions attached. Water Coolers of 80 Ltrs capacity (13 Units per year) Job 54 Supply and fixing of suitable size copper refrigerant piping with expanded polythene foam insulation tubing covering for A/C units. Mtr 55 Annual comprehensive maintenance & repair including attending preventive & breakdown maintenance of following Water Purifiers (with and without integral chiller units) by deputing authorized service dealer of RO/UVwater purifiers of different makes & capacities, installed at different places including replacement of filter cartridge, RO Membrane, carbon filter & defective parts/PVC pipes/Iron clamps, internal filter elements etc. with same company make spares including arresting the leaks etc. as required. 55.1 CMC of 10 Ltr Storage RO filter Cum UV water Purifier of make Eureka Forbes /Kent RO+ UV with all accessories for providing drinking, complete as required. (2 Units per year) Job 55.2 CMC of Hot and Cool type RO water filter Cum UV Purifier of make Eureka Forbes Model : Aquaguard RO+ UV with all accessoriesfor providing drinking water complete as required.(1 Unit per year) Job 55.3 CMC of the Aquaguard Pure Chill 60/80 UV Water Cooler cum purifier, make : Eureka Forbes, including replacement of compressor, filters, PCB, pumps/motors, U.V. Lamp etc. as per breakdown / preventive maintenance requirement.(2 Units per year) Job 55.4 CMC of Cooler cum Purifier of capacity 40 LPH, 3 stage purification, make : Eureka Forbes, model: Aquaguard AGCCP, Including replacement of Filters(pre filter & carbon filter), Solinoied Valve, PCB, U.V.Lamp etc. as per breakdown maintenance requirement. (4 Units per year) Job 55.5 CMC of Purifier of make : Eureka Forbes, model: Aquaguard AG -200, Including replacement of Filters(pre filter & carbon filter), Solinoied Valve, PCB, U.V.Lamp etc. as per breakdown maintenance requirement. (5 Units per year) Job 55.6 CMC of 25 LPH capacity RO+UV+UF water Purifier of make: Kent, Model :Elite Plus, with all accessories for providing drinking water, complete as required.(2 Units per year) Job 55.7 CMC of 50 LPH capacity RO+UV+UF water Purifier of make: Kent, Model :Elite Plus, with all accessories for providing drinking water, complete as required.(6 Units per year) Job 55.8 CMC of 40 LPH capacity RO filter Cum UV water Purifier of make: Kent, Model :Elite, with all accessories for providing drinking water, complete as required.(1 Unit per year) Job 55.9 CMC of 50 LPH capacity RO filter Cum UV water Purifier with all accessories for providing drinking water, complete as required. (4 Units per year) Job Total of SH: II SH:III : DSR ITEMS EXECUTION OF WORKS AS PER CPWD DELHI SCHEDULE OF RATES (E&M) 2022 WITH UPTO DATE SPECIFICATIONS, AS AND WHEN REQUIRED.
