Tender For Up Gradation Of Pumping Main Booster No 2 Under Ge Gwalior; 1 M&L For Construction Of Header Made Out Of Ms Pipe Of 600Mm Dia, ( Thickness Of Ms Pipe Not Less Than 12Mm ) , 4Mtr Length ( In Two Piece Of Each 2 Mtr Length ) , A Butterfly Valve 600 Mm Dia Fixed Centre Of Ms Pipe With Flange, Flanges Are Tighten With Nut Bolts And Washers Etc Complete And Providing Holes Forfixing / Welding Ms Pipe Pieces With One Flanged End For Fixing Of Sluice Valve Of Size 200 Mm Dia 05 Nos And 150 Mm Dia = 01 Nos. Ms Pipe Should Be Fixed On Pcc In Foundation And Top 1:3:6 Type C1 Using 20 Mm Graded Trap Stone Aggregate ( 30Cm In Foundation & 30 Cm On Top ) & Anchoring With Ms Strip At 03 Place ( Ms Strip Should Be Grouted In Pcc As Suitable ) And Masonary Block Constructed With 230 Mm Thick Bricks, Sub Class B Bricks Builts In Cement Mortar 1:4 And 15Mm Thick Plastering To Brick Masonary In Cement Mortar, Including Excavation And Earth Work Complete. Note ( I ) Quoted Rates Are Also Included To Fixing / Welding Ofmspipes Cut Pieces As Required Size / Type / Length On Site Each For All 06 Nos Inlet / Outlet Water Supply Pipeline Connections. & All Type Pcc Foundation & Brick Work Complete ( Ii ) All T&P, Materials Will Be Provided By The Contractor Without Any Extra Cost. ( Iii ) Ms Fittings Like, Flange, Dead Plate, Bends, Reducers Etc And Sluice / Butterfly Valves Should Be Measured And Paid Separetaly Under Appropriate Items Below. 2 Supply & Fix For Butterfly Valve Of Size 600 Mm And Connected With Necessary Bolts, Nuts & Washers, Gaskets Etc Complete All As Directed. 3 Supply And Fix Erw Ms Pipe 200 Mm Dia 8 Mm Thick Complete All As Specified And Directed. Note :- Flange Should Be Measure And Paid Separetaly 4 Supply And Fix And Welding Ms Flange 600 Mm Dia, 16 Mm Thick And Providing Holes For Fixing Of Nuts, Bolts Of Suitable Size Complete All As Specified And Directed. 5 Supply And Fix And Welding Ms Flange 400 Mm Dia, 16 Mm Thick And Providing Holes For Fixing Of Nuts, Bolts Of Suitable Size Complete All As Specified And Directed. 6 Supply And Fix And Welding Ms Flange 200 Mm Dia, 12 Mm Thick And Providing Holes For Fixing Of Nuts, Bolts Of Suitable Size Complete All As Specified And Directed. 7 Supply And Fix And Welding Ms Flange 150 Mm Dia, 12 Mm Thick And Providing Holes For Fixing Of Nuts, Bolts Of Suitable Size Complete All As Specified And Directed. 8 Supply And Fix Ms Dead Plate Of Size 600 Mm Dia, 24 Mm Thick And Providing Holes For Fixing Of Nuts, Bolts Of Suitable Size Complete All As Specified And Directed. 9 Supply And Fix Ms Dead Plate Of Size 200 Mm Dia, 12 Mm Thick And Providing Holes For Fixing Of Nuts, Bolts Of Suitable Size Complete All As Specified And Directed. 10 Supply And Fix Ms Dead Plate Of Size 150 Mm Dia, 12 Mm Thick And Providing Holes For Fixing Of Nuts, Bolts Of Suitable Size Complete All As Specified And Directed. 11 Supply And Fix Ms Bend Of Size 200 Mm Dia, 8 Mm Thick Complete All As Specified And Directed. 12 Supply And Fix Ms Reducer Of Size 400Mmx 200 Mm Dia, 12 Mm Thick Complete All As Specified And Directed. 13 Supply And Fix Cast Iron Sluice Valve Pn-1.6 Conforming To Is 14846 / 2000, Isi Mark With Ms Spindle And Iron Wheel Head With Both Ends Flanged With New Rubber Gasket, Bolts And Nuts Including Dismantling Of Old Unserviceable Sluice Valve Fixed At Any Location Of Size 200 Mm Dia All As Directed. 14 Supply And Fix Cast Iron Sluice Valve Pn-1.6 Conforming To Is 14846 / 2000, Isi Mark With Ms Spindle And Iron Wheel Head With Both Ends Flanged With New Rubber Gasket, Bolts And Nuts Including Dismantling Of Old Unserviceable Sluice Valve Fixed At Any Location Of Size 150 Mm Dia All As Directed. 15 Supply & Fix For Ci Non Return Valve ( Nrv ) Conforming To Is 5312, Isi Marked With Gm Flap Of Size 200 Mm And Connected With Necessary Bolts, Nuts & Washers, Gaskets Etc Complete Including Dismantling Of Old Unserviceable Non Return Valve All As Directed. 16 Supply & Fix For Ci Foot Valve Isi Marked With Half Round Double Gm Flap Of Size 200 Mm And Connected With Necessary Bolts, Nuts & Washers, Gaskets Etc Complete Including Dismantling Of Old Unserviceable Non Return Valve All As Directed. 17 Supply And Fix Cast Iron Air Valves With Two Air Outlets, Conforming To Is 14845 Of Size 80 Mm Dia Bore And Fixing Up In Cast Iron Water Supply Mains Of Size 400 Mm Dia. 18 Supply, Laying And Testing Di Pipes With Double Flangde Ends Centrifugally Cast, Class K-9 With Cement Mortor Lining Inside The Pipes & Zinc Coated Out Side As Peris8329 / 2000In Any Length Fixed On Pillar And Wall Of 200 Mm Bore Sizes All As Specified And Directed 19 M & L Cutting Of Existing Cast Iron Pipes In Position For Insertion Of Bends ( Any Type, Radius And Angle ) Tapers Any Type ( Straight Bends, Increasing, Decreasing Or Double Socket Etc ) Tee Pieces, Single Branch Y Junction, Double Branch, Cross ( All Sockets Or Sockets & Spigot ) Collars, Caps & Plugs For Flanged Of Pipes 200 Mm Dia Bore Branch Connection Etc All As Specified And Directed. Note : Di Special Fittings Shall Be Measured And Paid Separately 20 M&L, Fordi Fittings Such As Bends ( Any Type, Radius And Angle ) Tapers Any Type ( Straight Bends, Increasing, Decreasing Or Double Socket / Flanged Etc ) Tee Pieces, Single Branch Y Junction, Double Branch, Cross ( All Sockets Or Sockets & Spigot / All Flanged / Restrain Joint Etc ) Collars, Caps & Restrain Flanges, Plugs For Spigot Socketed / Flanged Pipes Upto 400 Mm Dia Bore 21 Rotational Moulded Polyethylene Water Storage Tanks ( Cylindrical Vertical With Closed Top ) Hoisted And Fixed In Position Of Capacity 500 Ltrs All As Specified 22 Supply & Fixing Galvanised Steel Water Tubing Of Medium Grade With All Fittings Such As Bends, Elbows, Tees, Unions, Nipples, Short Pieces Etc And Fixed Complete To Walls And Ceilings Or Laid In Floors All As Directed Of Size 25 Mm Dia Complete. Note:- ( I ) The Rates Quoted Inclusive Of Cutting, Jointing And Testing Of The Pipe. 23 S&F Gun Metal Gate / Ball Valves With Iron Wheel Head Screwed At Both Ends For Iron Pipes Complete Including Dismantling Of Old Unserviceable Gate Valve Fixed At Any Location Of Size 25 Mm Dia All As Directed 24 Supply And Fix In Replacement Fully Automatic Star Delta Startor Suitable For 150 Hp, Mccb Controller, 3 Phase , 415 Volts, 50 Hz Centrifugal Pump Set Complete. 25 Supply, Installation And Commissioning And Testing Of Cpri Approved Lt Panel Cubical Type Suitable For 415 Volts 3 Phase 4 Wire, 50 Hz Ac Supply System, Floor Mounted Outdoor Type Factory Fabricated Duly Powder Coated Inside And Out Side, Outer Cover Made Out Of 2.8 Mm Thick Crca Sheet, Internal Cover And Partition Made Out Of 3.15 Mm Thick Crca Sheet With Angle Iton 50Mm X 50Mm X 6Mm Covered From All Side With Front And Back Openable, Weather Proof Including Suitable Rating Aluminium Busbar For 3 Phase 4 Wire System, Wiring With Suitable Size Copper Cable And Embeded In Brickwork In Cm 1:4 Not Less Than 60 Cm Above Ground Level With Suitable Foundation For Fixing Panel Of Required Size In Ground With Nuts, Bolts And Washers Etc. Complete Comprising Of Following Including ( A ) Mccb 400 Amps 4 Pole , 415 Volts, 36 Ka, = 01 Nos, 415 Volts, 50 Ka, , ( B ) Mcb Spn 63 Amps 10 Ka = 01 Nos &Aluminium Bus Bar With Suitable Amps Capacity Nos 4, ( C ) Digital Voltmeter 0-500 Volts With Selecter Switch - 01 Nos ( D ) Digital Amp Meter 0-500 Amp With Selector Switch & Ct 01 No ( E ) Indicator Lamp Led Type ( R, Y, B ) Complete With Bakelite Fuse Fitting - 01 Set 26 Supply, Lay , Connecting Pvc Insulated Submersible Copper Cable 3 Core, 25 Mm², Woking Voltage 1100 Volts Complete All As Specified. 27 M & L For Laying Connecting And Testing Of 1100 Volts Grade Lt Xlpe Insulated Screened, Pvc Bedded Galvanised Steel Strip Or Wire Armoured, Heavy Duty Eletric Power Cable With Aluminium Conductor Of Size Cables 400 Sqmm 3.5 Core. 28 Excavating In Trenches Not Exceeding 1.5M Wide And Not Exceeding 1.5M In Depth And Getting Out For Laying Of Pipe Etc In Soft / Loose Soil. 29 Returning, Filling Including Spreading, Levelling, Watering And Well Ramming In Layers Not Exceeding 25Cm In In Soft / Loose Soil. 30 Removing Excavated Surplus In Soft / Loose Soil To A Distance Not Exceeding 50M And Depositing Where Directed And At A Level Not Exceeding 1.5M Above The Starting Point. 31 Sand Filling In Trenches With Clean Dry Unwashed Sand Free From Sharp Particles, Gently Punning Around The Cables Complete. 32 Bricks, Old Size Sub Class `B Laid In Trenches With Width Wise Along The Alignment Of The Cable As Protection Complete. 33 Supply, Installation And Commissioning And Testing Of Cpri Approved Lt Panel Cubical Type Suitable For 415 Volts 3 Phase 4 Wire, 50 Hz Ac Supply System, Floor Mounted Outdoor Type Factory Fabricated Duly Powder Coated Inside And Out Side, Outer Cover Made Out Of 2.8 Mm Thick Crca Sheet, Internal Cover And Partition Made Out Of 3.15 Mm Thick Crca Sheet With Angle Iton 50Mm X 50Mm X 6Mm Covered From All Side With Front And Back Openable, Weather Proof Including Suitable Rating Aluminium Busbar For 3 Phase 4 Wire System, Wiring With Suitable Size Copper Cable And Embeded In Brickwork In Cm 1:4 Not Less Than 60 Cm Above Ground Level With Suitable Foundation For Fixing Panel Of Required Size In Ground With Nuts, Bolts And Washers Etc. Complete Comprising Of Following Including Taking Out The Old Unserviceable Panel Complete All As Specified And Directed By Engineer-In-Chargeincoming:- ( A ) Acb 1000 Amp, 4 Pole, 50 Ka, Mdo Mp Based, 415 Volts Ac - 01 Nos ( B ) Aluminium Busbar 1500 Amp Rating Tpn- 04 Nos ( 02 Set As Incoming & Outgoing ) ( C ) Digital Voltmeter 0-500 Volts With Selecter Switch - 01 Nos ( D ) Digital Amp Meter 0-500 Amp With Selector Switch & Ct 01 No ( E ) Indicator Lamp Led Type ( R, Y, B ) Complete With Bakelite Fuse Fitting - 01 Set Outgoing:- ( A ) Mccb 4 Pole 600 Amps, 36 Ka, 415 Volts Ac-02 Nos ( B ) Mccb 4 Pole 250 Amps, 25 Ka, 415 Volts Ac-5 Nos ( C ) Spare Pocket For Fixing Mccb Upto 100 Amps -01 No 34 Taking Up Cast Iron Water Main ( Including All Fittings ) With Spigot And Socketed Ends And Lead Joints Including Burning Out Lead Joints For Pipe Of Bore 100 Mm Complete All As Specified & Directed. 35 Taking Up Cast Iron Water Main ( Including All Fittings ) With Spigot And Socketed Ends And Lead Joints Including Burning Out Lead Joints For Pipe Of Bore 300 Mm Complete All As Specified & Directed. 36 Supply, Laying And Testing Di Pipes With S / S Ends Centrifugally Cast, Class K-9 With Cement Mortor Lining Inside The Pipes & Zinc Coated Out Side As Peris8329 / 2000In Any Length Laid In Trenches Of 100 Mm Bore Sizes All As Specified And Directed :- Note : Excavation And Earth Work & Di Special Fittings Shall Be Measured And Paid Separately 37 Supply, Laying And Testing Di Pipes With S / S Ends Centrifugally Cast, Class K-9 With Cement Mortor Lining Inside The Pipes & Zinc Coated Out Side As Peris8329 / 2000In Any Length Laid In Trenches Of 300 Mm Bore Sizes All As Specified And Directed :- Note : Excavation And Earth Work & Di Special Fittings Shall Be Measured And Paid Separately
