Bids Are Invited For Serviceability Checks / Overhaul Of Electronic Equipment - ( A ) Clean Dust, Dirt And Moisture From The Internal And External Surface Of The Units. ( B ) Check Connectors For Proper Mating And Grounding. ( C ) Clean All Pcbs / Modules And Check For Correct Functionality. Procure And Renew If Faulty. ( D ) Smps / Power Supply Unit To Be Checked For Rated Input / Outputs. Renew If Faulty. ( E ) Systems Having Software To Be Checked For Correct Functionality. ( F ) Check The Cable And Connectors For Cuts, Corrosion Or Undue Strain. ( G ) Clean The Air Filter With Vacuum Cleaner As Applicable. ( H ) Check The Set For Optimum / Designed Performance And Reliability. ( J ) Replace The Defective Lamps / Caps / Fuses / Hinges / Screws / Knobs / Keys / Switches. ( K ) All Existing Shock Mounts / Base Plates / Foundations To Be Checked For Integrity And Renew If Necessary. ( L ) Renew All Earthing / Bonding Straps. ( M ) Renew All Terminal Lugs ( N ) Renew Of Emi / Emc Gaskets Of All Openings Of Equipment. ( P ) Interfacing To All Systems To Be Proved As Applicable. ( Q ) Carry Out All Annual Routines And Performances Tests As Per Maintop At Shop Floor , Post Overhaul / Serviceability Checks - Post Overhaul / Repair / Routines Following To Be Carried Out:- ( A ) All Systems / Equipments / Machinary Should Be Proved To Rated / Designed Power / Capacity Without Limitations / Observations And Trials To Be Offered To The Naval Trial Agencies For Design Specifications Along With Installation Inspections As Per Approved Wlds, Op Checks, Hats And Sats. ( B ) Any Unserviceability During Undertaking Above Serial Needs To Be Repaired / Renewed By Firm Inclusive Of Spares. ( C ) Vibration Levels At All Points Should Be Less Than 5 Mm / Sec.The Equipment Performance Will Be Considered Satisfactory Only If The Performance Trials Are Cleared By Naval Inspection Agency. ( D ) Present System For Hats And Sats As Per The Standards Of Watt. , Receiver Aerial - Exchange Make :Bel, Banglore Serial No : 902 Oems Local Representative : Bel, Banglore , Receiver Aerial Exchange ( I ) - Check Connectors For Proper Mating And Grounding Replace The Defective Ones , Receiver Aerial Exchange ( Ii ) - Check The Continuity Between Chassis And Earth It Should Not Exceed0.05 Ohms. , Receiver Aerial Exchange ( Iii ) - Procure / Replace Of Rf Feeder Cable ( Rg-213 ) Runs From Bridge Top Whip Antennas ( Port & Stbd ) To Receiver Aerial Exchange In Mco , Receiver Aerial Exchange ( Iv ) - Connectorisation Of Rf Feeder Cable With Aerial Exchange And Antennas , Receiver Aerial Exchange ( V ) - Post Overhaul / Serviceability Checks As Per Sow 4. , Ccs Mk Ii ( A ) - Make : Bel, Bengalore Model : Ccs Mk Ii Serial No : 201 Oems Local Representative : Bel Bangloreoverhauling Of Complete System As Per Sow 3. , Ccs Mkii ( B ) - Post Overhaul / Serviceability Checks As Per Sow 4. , Ccs Mkii ( C ) - Itu Show Sub Optimal Performance To Be Replaced , Ccs Mkii ( D ) - Performance Checks And Routine Of Following Sub Units To Be Carried Out. ( I ) Concentrator- 04 Nos., Itu-16 Nos., Co-Axial Modems-08 Nos., Communication Control Terminal ( Cct ) - 01 Nos., Intercom Unit-01 Nos., Af Monotoring Unit-01 Nos., Hf Power Monitor Unit-01 Nos., Serviceability Check Of All Pcbs Of Above Mentioned Units., Clean Dust, Dirt And Moisture From The Internal And External Surface Of All The Units, Check The Proper Functional Of Front Panel Switches Of All Units., Carry Out Functional Test And Prove For Satisfactory Performance Of Whole System., Present System For Hats And Sats As Per The Standards Of Watt And Liquidate All The Observations Of Watt. , Mandatory Spares Eb9036b / 100005119364 - Rfi Filter , Eb9036b / 114000659507 - Pb Assy ( Pre Amplifier ) , Eb9036b / 114000659604 - Pb Assy ( O / P Emitter Follower ) , Eb9036b / 114000671438 - Pb Assy ( Regulator ) , Eb9036b-114001789654 - I / O Controller , Eb9036b-114001789945 - Pb Assy Voice Mux-Demux , Eb9036b-114001790333 - Pb Assy ( Vdic-Itu ) , Eb9036b-114001790430 - Pb Assy Vdic-Cct , Eb9036b-114001790915 - Mother Board , Eb9036b-114001791691 - Lan Controller , Eb9036b-114002222565 - Pb Assy Vdic Rad Ser , Eb9036b-114001791012 - Smps Board , Eb9036b-114001791206 - Pb Assy Adac , Eb9036b / 480511030508 - Keyboard , Eb9036b / 450010550231 - Loud Speaker , Eb9036b / 114001723403 - Display , Eb9036b / 114001723694 - Pb Assy Controller , Eb9036b / 114001723888 - Pb Assy Signal Switching Total Quantity : 1
